文献类型：期刊文献

中文题名：钙镁负载型固体碱制备生物柴油的研究

英文题名：STUDY ON BIODIESEL PREPARING BY CALCIUM AND MAGNESIUM LOADED SOLID-BASE CATALYST

作者：黄慨[1];颜涌捷[1];陈晴[1];张素萍[1];任铮伟[1]

机构：[1]华东理工大学资源与环境工程学院,上海200237

年份：2009

卷号：30

期号：2

起止页码：249

中文期刊名：太阳能学报

外文期刊名：Acta Energiae Solaris Sinica

收录：CSTPCD;;EI(收录号：20091311991224);Scopus;北大核心:【北大核心2008】；CSCD:【CSCD2011_2012】；

基金：上海市科研计划项目(05DZ12033)

语种：中文

中文关键词：负载;固体碱;生物柴油;酯交换;氧化钙

外文关键词：load; solid base catalyst; biodiesel; transesterification; calcium oxide

摘要：研究了CaO-MgO/SiO_2负载型固体碱催化剂的制备条件,并对其进行XRD、FT-IR、BET和CO_2-TPD表征分析,仪器分析表明CaO成功引入到载体,MgO起助催化作用增强了碱性并研究该固体碱催化剂酯交换反应催化毛豆油制备生物柴油的条件。考查反应时间、反应温度、醇油比、催化剂用量和原料中水分含量的影响。研究表明,在反应时间6h,反应温度65℃,醇油比18:1,催化剂用量3%,原料油水份含量低于1%时,生物柴油收率可达95.4%,甘油收率达96%以上。
The preparation condition of CaO-MgO/SiO2 loaded solid-base catalyst was studied, and it was characterized by methods of XRD, FT-IR, BET and CO2-TPD. It showed that calcium oxide was embedded successfully into the silicon dioxide cartier, and its alkaline was enhanced by the magnesium oxide. Furthermore, the transesterification conditions from crude soybean oil to biodiesel were investigated using CaO-MgO/SiO2 solid-base catalyst. The main factors included reaction time, temperature, ratio of methanol to oil, the amount of catalyst and the moisture content in material. Experi- ment results show that trarsesterification of crude soybean oil can atten the better biodiesed products, the biodiesd yield is up to 95.4% and the glycerol yield is over 96.0% when the reaction time is 6 hours, the reaction temperature is 65~C, ratio of methanol to oil is 18： 1（mol ratio）, the amount of catalyst is 3% （w/woil）, the feedstock with high water content is below 1%.