文献类型：期刊文献

中文题名：煤快速热解固相和气相产物生成规律

英文题名：Formations of solid and gas phase products during rapid pyrolysis of coal

作者：袁帅[1];陈雪莉[1];李军[1];代正华[1];周志杰[1];王辅臣[1]

机构：[1]华东理工大学煤气化教育部重点实验室,上海200237

年份：2011

卷号：62

期号：5

起止页码：1382

中文期刊名：化工学报

外文期刊名：CIESC Journal

收录：CSTPCD;;EI(收录号：20112714112410);Scopus;北大核心:【北大核心2008】；CSCD:【CSCD2011_2012】；

基金：国家重点基础研究发展计划项目(2010CB227000);上海市优秀学科带头人资助计划项目(08XD1401306);大型气化炉完善化关键技术研究项目(08DZ1200200)

语种：中文

中文关键词：煤;快速热解;焦;热解气;热值

外文关键词：coal; rapid pyrolysis; char; pyrolysis gas; heating value

摘要：利用能有效避免二次转化反应的高频炉热解装置对3种不同变质程度的煤进行了600~1200℃条件下的快速热解,考察了在煤热解最初阶段焦产率、焦-C产率、热解气产率、热解气4种主要组分H2、CO、CH4和CO2的比例以及热解气热值随煤阶和热解温度的变化规律。结果表明,焦的产率和焦-C的产率均随煤阶的升高而升高,热解气的产率随煤阶的升高而降低;热解温度的提高能显著降低煤焦和焦-C的产率并提高热解气的产率。热解气组分以H2和CO为主,CH4和CO2的含量较低;随着温度的升高,H2和CO的含量升高,CH4和CO2的含量下降。热解气中H2＋CO的含量以及H2/CO的比值均随着温度的升高而升高。烟煤和无烟煤热解气热值均随着温度的升高而降低,褐煤热解气热值则先上升后下降。
The rapid pyrolysis of 3 different ranks of coals,including lignite from Inner Mongolia,bituminous from Shenfu coalfield,and anthracite from Guizhou,has been carried out in a high-frequency furnace which could sharply reduce the secondary reactions.The pyrolysis temperatures were ranged from 600℃ to 1200℃ with an interval of 100℃.The effects of coal rank and temperature on the yields of char,char-C,and pyrolysis gas,as well as the percentages of H2,CO,CH4,and CO2 in the pyrolysis gas produced from the primary stage of pyrolysis were investigated.Results show that both of the yields of char and char-C increase,while the yield of pyrolysis gas decreases as the coal rank increases.The yields of char and char-C decrease,and the yield of pyrolysis gas increases with the increasing temperature.The char-C yield of lignite can reach a level lower than 50% at the temperature of 1200℃.H2 and CO are the main components of the pyrolysis gas,while the contents of CH4 and CO2 are much lower.As the temperature increases,the contents of H2 and CO increase,and the contents of CH4 and CO2 decrease.The contents of H2＋CO in pyrolysis gas increase with the increasing temperature.The H2＋CO contents from 3 coals are all higher than 90% at the temperature of 1200℃.The H2/CO ratio of pyrolysis gas also increases as the temperature increases.Both the H2＋CO contents and H2/CO ratio in pyrolysis gas from 3 coals are in the order of anthracitelignitebituminous.The low heating values of pyrolysis gas from all the 3 coals are higher than 11 MJ·m-3.As the pyrolysis temperature increases,the low heating values of pyrolysis gas of bituminous and anthracite decrease,while the heating values of pyrolysis gas of lignite have a peak value at the temperature about 1000℃.