文献类型：期刊文献

中文题名：有机溶剂浸取湿法磷酸脱氟渣制备磷酸的研究

英文题名：Study on preparation of phosphoric acid by leaching fluoride residue from wet?process phosphoric acid with organic solvents

作者：付子启[1];张程[1];盛勇[2];纪利俊[1]

机构：[1]华东理工大学化工学院,上海200237;[2]中化云龙有限公司

年份：2022

卷号：54

期号：7

起止页码：129

中文期刊名：无机盐工业

外文期刊名：Inorganic Chemicals Industry

收录：CSTPCD;;北大核心:【北大核心2020】；CSCD:【CSCD_E2021_2022】；

语种：中文

中文关键词：湿法磷酸;脱氟渣;浸取;响应面法

外文关键词：wet?process phosphoric acid;fluoride residue;leaching;response surface methodology

摘要：脱氟渣是湿法磷酸化学沉淀脱氟过程产生的固体废渣。分别用甲醇、乙醇和丙酮浸取脱氟渣来回收脱氟渣中的磷酸,研究了浸取时间、温度和液固比对于五氧化二磷、氟的浸取率以及浸出液磷氟比[m(五氧化二磷)/m(氟)]的影响,得到了适宜的浸取条件。浸取液经蒸发浓缩回收浸取剂后,浓缩液均可满足饲料级磷酸氢钙生产对于湿法磷酸磷氟比的要求。综合考虑浸取剂成本、五氧化二磷浸取率和浸出液磷氟比,确定甲醇为优选浸取剂,并用响应面法对甲醇浸取工艺条件进行优化。优化工艺条件下五氧化二磷的浸取率为97.13%、浸出液磷氟比为51.62,甲醇在5次循环回收利用后对脱氟渣仍有较好的浸取效果。
The fluoride residue is a solid waste produced in the chemical defluorination process of wet-process phosphoric acid.The effects of leaching time,temperature and liquid-solid ratio on the leaching ratio of P_(2)O_(5) and F and the phosphorfluorine ratio[m(P_(2)O_(5))/m(F)]were studied by using methanol,ethanol and acetone to leach the fluoride residue for recycling phosphoric acid.The suitable leaching conditions were obtained.After the leaching solution was evaporated and concentrated to recover the leaching agent,the concentrated solution all could meet the requirements of the m(P_(2)O_(5))/m(F)of wet-process phosphoric acid for producing feed-grade calcium hydrogen phosphate.Considering the cost of the leaching solvents,the leaching ratio of P_(2)O_(5) and m(P_(2)O_(5))/m(F),methanol was selected as the optimal leaching solvent,and the leaching conditions of methanol was optimized by response surface methodology.Under the optimized conditions,the leaching ratio of P_(2)O_(5) was 97.13%,and the m(P_(2)O_(5))/m(F)of the leaching solution was 51.62.After 5 cycles of solvent recovery and leaching,recovered methanol still had good leaching effect on the fluoride residue.