文献类型：期刊文献

中文题名：氯化锌活化制备沥青基球形活性炭

英文题名：Preparation of Pitch-Based Spherical Activated Carbons by ZnCl_2

作者：刘小军[1];王永邦[1];乔文明[1];梁晓怿[1];凌立成[1]

机构：[1]华东理工大学化学工程联合国家重点实验室,上海200237

年份：2010

卷号：36

期号：4

起止页码：523

中文期刊名：华东理工大学学报（自然科学版）

外文期刊名：Journal of East China University of Science and Technology

收录：CSTPCD;;Scopus;北大核心:【北大核心2008】；CSCD:【CSCD2011_2012】；

基金：上海市科学技术委员会资助项目(09495801200);华东理工大学优秀青年教师科研专项基金(YA0157114)

语种：中文

中文关键词：沥青;活性炭;化学活化法;ZnCl2

外文关键词：pitch; activated carbon; chemical activation; ZnC12

摘要：采用ZnCl2化学活化法和水蒸气物理活化法制备了系列沥青基球形活性炭。研究了活化工艺对最终活化样品孔隙结构的影响;对比分析了在具有相近BET比表面积和总孔孔容时,两种活化方法对所制得样品孔径分布的影响。结果表明:在活化温度为500℃、ZnCl2与碳浸渍质量比为2∶1、活化时间为3 h时,ZnCl2活化样品具有最佳的BET比表面积,为961 m2/g。与传统的水蒸气物理活化法相比,ZnCl2化学活化法更有利于中孔结构的发展。
A series of pitch-based spherical activated carbons （PSACs） were prepared by chemical activation with zinc chloride and physical activation with steam. The influence of activation process variables such as chemical ratio, activation temperature and holding time on the pore structure of PSACs was studied. The two series of PSACs with similar BET specific surface areas and total pore volume were also compared. The results show that PSAC with optimum BET specific surface areas （961 m^2/g） was obtained under the activation temperature of 500 ℃, ZnC12/carbon mass ratio of 2 ： 1 and the holding time of 3 h. Compared with the conventional steam activation, ZnCl2 chemical activation is more propitious to create mesopore structure.